What all have you broken while wheeling?

[Logan]

Inspired by this thread: http://pirate4x4.com/forum/showthread.php?t=639000&highlight=worst+breakage


Mine is still kind of easy to list because I've only had the rig for a year and a half, I can still list mine by wheeling trips:

Gulches Jan 09
-Fuel pump

River Rock May '09
-motor mount

Aetna August '09
-bent LCA mount on axle
-pretzeled track bar
-bent both UCA's
-tore off part of the front bumper
-bent tie rod

Choccolocco March '10
-destroyed the aluminum steering box spacer

Choccolocco June '10
- busted radiator

Also I don't know if I can contribute it to just one wheeling trip, but my steering box is dieing.


So what all have you broken or had fail on your rig while wheeling?  I know some of you have a much more impressive list than me.

[mdo817]

Don't know if I can do it by trip. Sure I will add stuff as it comes to me, I suffer from "oldtimers"
Tellico- Rear pinion yoke, shock mount
DTown- Sheared steering box bolts, fractured unibody (undetected at the time)
Rices Creek- Sheared steering box bolts, finished breaking unibody
Mountain Side- Cut tire down, power steering pump
Choccolocco- Rear Pinion Yoke
Allsouth Christmas Party- Bent rear drive shaft
River Rock- Trailer bearing
River Rock- Trailer tire (different trip)
River Rock- Right front leaf spring and centering pin
Some Where?- Locking Hub, several high steer studs

[ghostdancer308]

River Rock- rear Locker
Morris Mtn- Front track bar bracket

[swamprat]

09'

blew up a D44 and it burst into flames
pinion gear on a D35
ripped steering box section of frame off my old XJ
about 3 pairs of headlights and taillights
a set of fenders and header panel
only one U-joint
busted the rear hatch
and my pride when i tried to rock crawl in my manual XJ

10'

nothing so far

[kvom]

Old TJ:

 slave cylinder tube
 upper stock control arms (several times)
 Spindle bearing burnup (couple of times)
 brake master cylinder
 winch due to flexing winch plate
 steering box (worn out, not broken)
 front short side axle shaft (spread ears, D44)
 front lower control arm weld
 CB antenna
 flares

New old TJ

 Steering box shaft

[Krawler00]

 {ehm} More than that... Moab ring a bell. ;D

Me... not a thing for 8 years. {toast}

[mdo817]

{ehm} More than that... Moab ring a bell. ;D

Me... not a thing for 8 years. {toast}

What about your sliders and you wittle toe.

[lt99ls1]

Popped a tire off a rim twice.
CPS went out.
Dana 70 twice.  ;D
4 front drive shafts
1 Rear drive shaft
2 Rear dana 60 yokes

[ranger11]

{ehm} More than that... Moab ring a bell. ;D

Me... not a thing for 8 years. {toast}

What about your sliders and you wittle toe.

I remember something about a shock and control arm mount and something in the rear end.  ;D

[drich394]

Popped a tire off a rim twice.
CPS went out.
Dana 70 twice.  ;D
4 front drive shafts
1 Rear drive shaft
2 Rear dana 60 yokes

and your head @ RR ......

[Jimmy]

D30 axle shafts/u-joints x4
Rear brakeline x2
Stock 8.25 diff cover
Motor Mount
Fan Relay
Stock tierod x2
Rugged ridge tierod
35" tire
Sheet metal x infinity

[drich394]

front clip from Xj (snatched off by a passing tree)
trany
2 tcases- one 242 and on2 231
ring&pinion on D35
motor mount
about 20 front D30 shafts( not only the Ujoint)
sheet metal
shock mount
front driveshaft
jeep wiring  {ehm} - shut my junk down :bs)
wheel studs
an entire '99 XJ (roller)
rear 8.25 yoke and drive shaft on buddies jeep
rear D60 yoke straps and ujont on drive shaft